极速赛车怎么买

极速赛车怎么买 > 消息资讯 > 公司消息 >

简述低氮燃烧器和普通燃烧器的优弊病

时间:2018-08-24 12:04    作者:admin 返回列表

最近有客户找到我们北京创为,咨询低氮燃烧器和普通燃烧器的优弊病,针对这一问题,我们的技巧人员给出了以下解答。 Recently, a customer found us Beijing Chuangwei, consulting low nitrogen burner and ordinary burner advantages and disadvantages, in view of this problem, our technical personnel gave the following answers.

一、优点:
First, advantages:

1、由于拉伸了燃烧区域,削弱了部分燃烧强度,在必定时间内,克制了NOx的形成。
1. Because of stretching the combustion zone, the combustion intensity is weakened and the formation of NO_x is inhibited in a certain period of time.

2、低负荷燃烧安稳。因为减少了下部风量,使燃料在低浓度燃烧时,也非常安稳。甚至可以做到40%负荷牢固燃烧。
2, low load combustion stable. Because the air volume at the bottom is reduced, the fuel is also very stable when it burns at low concentration. It can even achieve 40% load stable combustion.

3、低负荷时,炉膛火焰充满度较好。水冷壁吸热均匀。
3, low load, furnace flame full degree is better. The water wall is uniform in heat absorption.
简述低氮燃烧器和普通燃烧器的优弊病

二、弊病:
Two, disadvantages:

1、由于燃尽风地位,使大批的送风在离开炉膛都未参加燃烧,而这部分热风也是从空预器吸收了大批热量的,因此会造成排烟温度过低的现象。尤其是在低负荷时。
1. Because of the position of exhaust air, a large number of air supply does not participate in combustion when leaving the furnace, and this part of hot air also absorbs a large amount of heat from the air preheater, so it will cause the phenomenon of low exhaust temperature. Especially at low load.

2、由于削弱了下部炉膛的进风量,使下二次风的托扶能力削弱,排渣量增长,排渣含碳量增长,尤其是高负荷时。
2. Because of weakening the air inlet of the lower furnace, the supporting capacity of the lower secondary air is weakened, the slag discharge is increased, and the carbon content of the slag is increased, especially at high load.

3、由于削弱了下部炉膛的进风,使风的刚性削弱,燃烧区域扩大,高负荷时,容易涌现水冷壁结焦。
3. Because of weakening the inlet air of the lower furnace, the rigidity of the air is weakened, the combustion area is enlarged, and the water wall is easy to coke at high load.

4、由于炉膛下部缺氧燃烧,产生大批还原性气体,使灰熔点降低,甚至造成冷渣斗都有结焦的现象。
4. Because of the anoxic combustion in the lower part of the furnace, a large amount of reducing gas is produced, which makes the ash melting point lower and even causes the phenomenon of coking in the ash hopper.

5、由于燃烧区域的拉伸,在高负荷时代,会造成过热器超温,减温水量不足的现象,严重时,甚至造成屏过结焦。
5. Due to the stretching of the combustion zone, the superheater will overheat and the cooling water will be insufficient during the high load period, and even cause the screen to be over-coked.

6、由于大批还原性气体和燃烧区域的扩大,使水冷壁中下部结焦严重,因脱焦造成的灭火、爆燃、损坏捞渣机现象都有产生。
6. As a result of the expansion of a large number of reductive gases and combustion area, the coking in the middle and lower parts of the water wall is serious, and the phenomena of fire extinguishing, deflagration and damage to the dregs dredger caused by decoking all occur.

7、由于高负荷时的结焦影响了水冷壁吸热,使炉膛下部温度上升,而燃尽风由于地位只能对炉膛上部的烟气进行冷却,而对下部炉膛温度毫无影响,因此炉膛下部NOx的产生随着结焦而增长,高负荷持续时间越长,减少NOx的效果就越小,甚至超出原有NOx量。
7. Because the coking at high load affects the heat absorption of the water wall and the temperature of the lower part of the furnace rises, and the burnout air can only cool the flue gas at the upper part of the furnace, but has no effect on the temperature of the lower part of the furnace, the production of NO_x in the lower part of the furnace increases with the coking, the longer the duration of the high load is, the effect of reducing NO_x is reduced. The smaller, even beyond the original NOx.

8、炉膛下部燃烧挥发分,上部燃烧焦炭的理论,和煤粉燃烧"挥发份析出→挥发份燃烧→焦炭燃烧→表壳灰分剥离,挥发分随着表壳灰分的剥离不断析出"的理论不相符。因此,高负荷时,大批煤粉的燃烧时间拉长,未完整燃烧的煤粉被带入烟道。造成飞灰含碳量增长。
8. The theory of burning volatile matter in the lower part of the furnace and burning coke in the upper part is inconsistent with the theory of "volatile matter precipitation, volatile matter burning, coke burning, ash peeling off from the surface shell, and volatile matter continuously precipitating out with ash peeling off from the surface shell" in pulverized coal combustion. Therefore, at high load, the combustion time of a large number of pulverized coal is lengthened, and the incompletely burned pulverized coal is taken into the flue. The carbon content of fly ash increases.

低氮燃烧器,通过调节燃烧空气和燃烧头,可以获得最佳的燃烧参数。渴望对大家有所援助。
Low nitrogen burner can obtain the best combustion parameters by adjusting the combustion air and combustion head. We hope to help you.

上一篇:低氮燃烧器的原理是什么 下一篇:安装低氮燃烧器的必要性

Copyright © 2018 北京创为机电设备有限公司 (http://gz-zhongyi.com) 专注于低氮燃烧器设计、改革、销售安装,锅炉低氮改革锅炉掩护保养网站地图极速赛车怎么买   备案号:京ICP备17061108号-1

技巧支撑:
极速赛车网上投注app-在线下载! 极速赛车投注——官网 极速赛车网-全网最高赔率彩票网 极速赛车网址 极速赛车网上投注-值得信任的投注平台 极速赛车网上投注-全网独此一家! 极速赛车投注平台-盛龙彩票 极速赛车投注平台 极速赛车投注网站 极速赛车投注网站-盛龙彩票